The leakage of generator set may be caused by the leakage of water pump, radiator and water pipe. Today, for the leakage of generator set, we share some treatment methods commonly used by technical service engineers. I hope I can help you.

1、解決淡水泵漏水問題

1. Solve the problem of water leakage of fresh water pump

（1）如果新鮮水泵監控孔也泄漏，請從閥體上取下新鮮水泵并拆卸，然后更換水封。

(1) If the fresh water pump monitoring hole also leaks, remove the fresh water pump from the valve body and disassemble it, and then replace the water seal.

（2）當安裝在新鮮水泵上的排水閥由于彈簧損壞而泄漏時，可以更換彈簧或新的排水閥。維護人員應在排水閥的彈簧上涂潤滑脂，以防止彈簧生銹。

(2) When the drain valve installed on the fresh water pump leaks due to spring damage, the spring or a new drain valve can be replaced. The maintenance personnel shall apply grease on the spring of the drain valve to prevent the spring from rusting.

2、散熱器漏水的解決方案

2. Solution of radiator leakage

（1）散熱器上下水室的維修方法：在檢測到散熱器的泄漏部分后，清潔泄漏的部分，然后用金屬刷或刮刀完全清理干凈金屬漆和鐵銹，然后用焊錫**。如果上下水室的固定螺釘中有大面積的漏水現象，可以將上下水室拆除，然后重新制作兩個尺寸合適的水室。在組裝上下水室之前，在墊片的***部和底部涂上粘合劑或密封劑，然后用螺釘將其固定。

(1) Maintenance method of radiator upper and lower water chamber: after detecting the leaking part of the radiator, clean the leaking part, and then completely clean the metal paint and rust with a metal brush or scraper, and then use solder * *. If there is a large area of water leakage in the fixing screws of the upper and lower water chambers, the upper and lower water chambers can be removed, and then two water chambers with appropriate size can be made again. Before assembling the upper and lower water chambers, apply adhesive or sealant to the * * * part and bottom of the gasket, and then fix it with screws.

（2）散熱器水管的維修方法：如果在檢測過程中發現散熱器外水管的損壞面較小，可以通過焊接進行維修。如果損壞的部分很大，請使用尖嘴鉗鉗住損壞的管子的管端，以免其泄漏。但是，堵塞的管道數量不能過多，否則會影響散熱器的散熱效果。如果散熱器的內部水管損壞，請拆下上下水室，并更換或焊接散熱器的內部水管。

(2) Maintenance method of radiator water pipe: if the damaged surface of radiator outer water pipe is found to be small during the inspection, it can be repaired by welding. If the damaged part is large, use pointed nose pliers to clamp the pipe end of the damaged pipe to avoid leakage. However, the number of blocked pipes should not be too large, otherwise it will affect the heat dissipation effect of the radiator. If the inner water pipe of the radiator is damaged, remove the upper and lower water chambers and replace or weld the inner water pipe of the radiator.

3、水管泄漏解決方案當水管因老化而泄漏時，應立即換上新的水管。如果水管很難買到，可以用防水膠帶包裹。如果是因?yàn)閵A子生銹而發生漏水，則可以將夾子更換或用電線包裹。

3. Solution of water pipe leakage when the water pipe leaks due to aging, it shall be replaced with a new water pipe immediately. If water pipes are hard to buy, they can be wrapped with waterproof tape. If the water leakage is caused by the rust of the clip, the clip can be replaced or wrapped with wire.

以上就是為大家介紹的有關沼氣發電機組http://www.shgcmy.com的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以專業的態度,為您提供服務

The above is about the biogas generator set introduced to you http://www.shgcmy.com I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service